Little Orange Cat build 2009-10 Season

[SHMO]

The sled is looking really good Michael. I actually like that blue motor against the orange. I did not think it would work out as well as it did. I would like to add that these pictures do NOTHING for the actual colors and attention to detail you are putting into the sled. Really nice build!

I look forward to seeing the copper color for the other sled build you're doing!

Offroad Engineering, he ran a dedicated heat exchanger to supply the intercooler. It consists of a heat exchanger at the very tail of the tunnel that runs up to the clutch side of bulkhead with aluminum tubing. It looks to me like it should be pretty effective.

SHMO

 

[little_orange_cat]

I just got the other sled today it looks sick its like a red orange and copper color you got to check it out I'm gonna start its thread tomorrow under the m series

offroad engineering; I used a separate cooler in the back of the tunnel close to the mud flap. If i taped in to the sleds cooling system it would actually be heating the W2A not good.

 

[jgw50]

Looks very very nice. What pump are you using for the IC?

 

[little_orange_cat]

Looks very very nice. What pump are you using for the IC?

I'm using a pump out of one of those pop up trailer tents. Its called a supper pump.

 

[little_orange_cat]

fuel system

Now i finished the wiring and the fuel system. It took a while trying to make everything compact and out of the way also having to make all the wires move with the new adjustable handlebar risers.

my friend mentioned that i didn't address what i was putting on the sled so here it is

I have a 1200 D&D big bore with a boondocker turbo system slightly modified with a 35/82 garret turbo. the sled is a 2007 with the extra wide front end and the 2009 M skid and rear bumper.

 

[little_orange_cat]

more plumbing and wiring

I finished mounting and plumbing the water to air intercooler. Then I finished running all the boost lines.

 

[Klimbing Kitty]

Dam!!Have to get a mop to wipe up my drool

 

[stonehands]

Hi everyone this is Troy. Looking good Michael. Whats up with the crappy paint job on the motor. What shotty paint shop did that work. Looks like they moved a bunch of crap out of the way and painted it in the garage.

 

[harf69]

i thought it looked sweet where did you get the air to water intercooler from is that something you can buy?

 

[little_orange_cat]

i thought it looked sweet where did you get the air to water intercooler from is that something you can buy?

yeah just check out frozenboost.com.
They have a tone of sweet stuff and its about the cheapest around

 

[zebiraross]

What track speeds do you see with this sled in deep snow?

 

[little_orange_cat]

I normally see Around 95-MPH it relay depends on what gearing and boost I'm running though i could get allot more but thats enough for my area.

 

[little_orange_cat]

almost done

Hey you all I just got her together and started. shes running good so now I have to do a few last minute touches and tomorrow morning I'm gonna go test it out in my Buddy's Field I'm gonna tape it. If I can figure out how to load it on to here I will.

 

[Boondock]

SICK sick sled!

 

[hatchers]

hope the water IC pump works for ya, any idea on the amp load for this pump?

i would keep this pump off the 12V circuit for the fuel pump, just a thought

95MPH track speed?, you need to gear down

 

[Snowedunder]

track

What track will you be using, 174? What about fuel at higher boost. Is there any places in you're area to buy a drum or two of race fuel.

 

[little_orange_cat]

I'm gonna run a 162 attack and I'm a dealer for fuel I'm gonna run 119 trick for now. until I start turning the boost up.

 

[Snowedunder]

Fuel

could you let me know how to get a hold of a barrel or two,my# is 604 202 4544,down you're way working right now. watched you're sled at big dawg, it was impresive then. new build looks pretty sweet.