Bog/engine cutting out on my 12 Pro

[Kale]

Just developed a bog/engine cuts out on my 12 Pro. Have about 400 miles and it happens spordacially off idle after I've let my sled sit. Searched the forums but haven't found info. on an off idle bog/engine cutting out. When I take off the sled sometimes cuts out and almost throws me over the handlebars. After about 100 yards of these issues it clears itself and runs fine. Didn't happen after every stop.

Thanks in advance,

Kale

 

[jwentzer]

TPS need adjustment? They are sporadic at times on all sleds.

 

[hipockets]

Check the throttle freeplay and tighten the cable. Should only have .010" to .030" measured between the lever and throttle block.

 

[DLynn]

My TPS had moisture inside of it. Caused all kinds of problems. Bog, low idle, no reverse. The dealer blew it out with air (could have been HOT air) and it seems to be working.

 

[Vertical Xtreme]

When you take off after sitting a few minutes the water temp drops pretty fast and I think the cold shot of water, along with the pipe loosing heat maybe is causing this. That is probably why it clears up soon too. I let my sled temp level off before i take off from a break. Only takes about 10-15 seconds more.

 

[Tree Boss]

When you take off after sitting a few minutes the water temp drops pretty fast and I think the cold shot of water, along with the pipe loosing heat maybe is causing this. That is probably why it clears up soon too. I let my sled temp level off before i take off from a break. Only takes about 10-15 seconds more.

Yep if you let your sled sit for just a minute or longer it will bog and not let you get into the throttle til it warms back up. Mine does it but I just wait for the temp to get to 120+ and it never misses a beat

 

[Kale]

Thanks for input.

Rode sled on Sunday, much easier ride than Saturday, and sled never had a problem. Could stop and let sled sit, start it up and hit throttle, and sled didn't hesitate.

Thanks again in advance,

Kale